35-13045-190WATER PRODUCTSCOMPANYA DIVISION OF A. O. SMITH CORPORATIONWATER PRODUCTSCOMPANYA DIVISION OF A. O. SMITH CORPORATIONInstallationUser andSe
8 Instruction manual TWI 35-130 G/TWI 45-190 G Remark Supplements or later adjustments and/or additions to any regulations, requi
Instruction manual TWI 35-130 G/TWI 45-190 G 9Chapter Target groups Description2. Operation of the device This chapter describes the operatio
10 Instruction manual TWI 35-130 G/TWI 45-190 GIntroduction1Chapter Target groups Description11. Warranty (certifi cate) This chapt
Instruction manual TWI 35-130 G/TWI 45-190 G 11 2 Operation of the device2.1 Introduction This chapter will cover in the given o
12 Instruction manual TWI 35-130 G/TWI 45-190 GOperation of the device22.3 Heating cycle of the device2.4 Security of the dev
Instruction manual TWI 35-130 G/TWI 45-190 G 132.4.2 Security of the water temperatureThe safety switch or ECO (Energy Cut-Off) switches of
14 Instruction manual TWI 35-130 G/TWI 45-190 G22.5 Safety of the installation Apart from the standard security of the device, t
Instruction manual TWI 35-130 G/TWI 45-190 G 153.1 Introduction3.2 Packaging3.3 Ambient conditions Warning The installation shall be carried
16 Instruction manual TWI 35-130 G/TWI 45-190 GWater compositionHardness(alkaline earth ions) > 1.00 mmol/l: - German hardness
Instruction manual TWI 35-130 G/TWI 45-190 G 17 Remark When installing the device, make sure that the device cannot damage the immediate su
www.aosmithinternational.comyour installer
18 Instruction manual TWI 35-130 G/TWI 45-190 GDimensions (all sizes in mm, unless stated otherwise)Installation33.4 Technical s
Instruction manual TWI 35-130 G/TWI 45-190 G 19Description I2H Unit TWI 35-130 TWI 45-190Gas category 2H: G20 – 20 mbarNominal load (Upper va
20 Instruction manual TWI 35-130 G/TWI 45-190 G3Installation3.5 Connections diagramLegendsNot mentioned numbers are not applicable
Instruction manual TWI 35-130 G/TWI 45-190 G 213.6 Water connections unvented3.7 Water connections vented Warning The installation sha
22 Instruction manual TWI 35-130 G/TWI 45-190 G3Installation3.8 Gas connection3.9 Air supply and fl ue gas discharge 1. Mount th
Instruction manual TWI 35-130 G/TWI 45-190 G 23 Device typesIMD-0531 R0
24 Instruction manual TWI 35-130 G/TWI 45-190 GDevice Diameter Maximum length Maximum num-ber of 90° bends TWI 35-130 80/125 20
Instruction manual TWI 35-130 G/TWI 45-190 G 25IMD-0532 R0Device with concentric fl ue gas discharge materialAccording to the table the maximu
26 Instruction manual TWI 35-130 G/TWI 45-190 GSpecifi cation of concentric roof fl ue terminal C333.9.4 Parallel connectionsThe t
Instruction manual TWI 35-130 G/TWI 45-190 G 27 Device with parallel fl ue gas discharge materialIMD-0533 R0 Use the longest pipe to
Instruction manual TWI 35-130 G/TWI 45-190 G 1
28 Instruction manual TWI 35-130 G/TWI 45-190 G Warning The installation shall be carried out by a recognised installation engin
Instruction manual TWI 35-130 G/TWI 45-190 G 29Connector blockLegendsA. screwsB. cover plateC. connector blockD. strain reliefFor preparation
30 Instruction manual TWI 35-130 G/TWI 45-190 G3.10.3 Connect the mains voltageThe device is delivered without power cable and ma
Instruction manual TWI 35-130 G/TWI 45-190 G 31LegendsNot mentioned numbers are not applicable.1. screws2. cover plate3. sealing cap4. CO2 se
32 Instruction manual TWI 35-130 G/TWI 45-190 G3.11.2 Adjust the CO2-valueFor preparation remove the cover plate (2) from the ele
Instruction manual TWI 35-130 G/TWI 45-190 G 33 4 Conversion to another gas category Conversion to another gas category is not
34 Instruction manual TWI 35-130 G/TWI 45-190 G 4 Conversion to another gas category
Instruction manual TWI 35-130 G/TWI 45-190 G 35LegendsNot mentioned numbers are not applicable.1. pressure reducing valve (obligatory)3.
36 Instruction manual TWI 35-130 G/TWI 45-190 G 5 Fill5.1.1 Fill unvented installationsProceed as follows for fi lling the dev
Instruction manual TWI 35-130 G/TWI 45-190 G 37LegendsNot mentioned numbers are not applicable.1. pressure reducing valve (obligatory)3.
2 Instruction manual TWI 35-130 G/TWI 45-190 G
38 Instruction manual TWI 35-130 G/TWI 45-190 G 6 Drain6.1 Drain unvented installations6.2 Drain vented installationsFor
Instruction manual TWI 35-130 G/TWI 45-190 G 397.1 Introduction7.2 Start up7.3 Heating cycle of the deviceThis chapter will cover in the g
40 Instruction manual TWI 35-130 G/TWI 45-190 G 7 Start upThe electronic control will then attempt to ignite the burner again t
Instruction manual TWI 35-130 G/TWI 45-190 G 41You can:• Shut down the device for a short time;• Electrically isolate the device;• Shut do
42 Instruction manual TWI 35-130 G/TWI 45-190 G 8 Shut down
Instruction manual TWI 35-130 G/TWI 45-190 G 43A distinction is made between:• General errorsGeneral errors are not visible on the control. G
9.2 Troubleshooting table for general errors Warning Maintenance shall only be carried out by a service and maintenance engineer.General errorsInst
Instruction manual - TWI 35-130 G/TWI 45-190 G 45Algemene storingenSymptom Cause Solution RemarkInsuffi cient or no hot waterThe device is off S
46 Instruction manual TWI 35-130 G/TWI 45-190 GInstruction manual - TWI 35-130 G/TWI 45-190 G 469.3 Troubleshooting table
Instruction manual TWI 35-130 G/TWI 45-190 G 47Instruction manual - TWI 35-130 G/TWI 45-190 G 47Pannes s’affi chant sur la commandeLigh
Instruction manual TWI 35-130 G/TWI 45-190 G 3 Warning Carefully read this manual before starting up the device.Not reading this manual and
48 Instruction manual TWI 35-130 G/TWI 45-190 GInstruction manual - TWI 35-130 G/TWI 45-190 G 48Light pul
Instruction manual TWI 35-130 G/TWI 45-190 G 49Service shall be carried out at least once a year both on the gas side and on the water side.
50 Instruction manual TWI 35-130 G/TWI 45-190 G10.3.1 DescaleScaling depends on the water condition and the water demand. Besides
Instruction manual TWI 35-130 G/TWI 45-190 G 51In order to register your warranty, please fi ll in the enclosed warranty card and return this
52 Instruction manual TWI 35-130 G/TWI 45-190 GWarranty (certifi cate)11The warranty referred to in Articles 1 and 2 does not apply
Instruction manual TWI 35-130 G/TWI 45-190 G 53This annex contains: • The Electrical circuit diagram.• Legends12.1 Introduction 12 An
54 Instruction manual TWI 35-130 G/TWI 45-190 GAnnex12IMD 0380 429 R01 = brown, 2 = blue, 3 = green, 4 = black, 5 = white, 6 = gre
Instruction manual TWI 35-130 G/TWI 45-190 G 55 WIRING = brown = blue = green = black = white = r
56 Instruction manual TWI 35-130 G/TWI 45-190 GAnnex12
Instruction manual TWI 35-130 G/TWI 45-190 G 57 IndexAair humidity 16air pressure switch 13ambient conditions 15ambient temperature 16Bb
4 Instruction manual TWI 35-130 G/TWI 45-190 G
58 Instruction manual TWI 35-130 G/TWI 45-190 GIndexRreduction valve 14regulations 7Ssafety 14scale 50security 11service 10,49serv
Instruction manual TWI 35-130 G/TWI 45-190 G 59
60 Instruction manual TWI 35-130 G/TWI 45-190 G0308 489 R1.0
Instruction manual TWI 35-130 G/TWI 45-190 G 5 Table of content 1 Introduction - - - - - - - - - - - - - - - - - - - - - - - - - -
6 Instruction manual TWI 35-130 G/TWI 45-190 G 11 Warranty (certifi cate)- - - - - - - - - - - - - - - - - - - - - - - - - - -
Instruction manual TWI 35-130 G/TWI 45-190 G 7 1 1.1 About the device 1.2 What to do when you smell gas1.3 RegulationsIntroductionThis ma
Comments to this Manuals